Transmission finally out
Moderators: jifflemon, coyote1980, Rachel
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
Transmission finally out
Finally!! long nose pliers & a good hard tug (oooer) got the speed sensor out
but...... the diaphram springs are covered in a film of black oil.
is this bad?
but...... the diaphram springs are covered in a film of black oil.
is this bad?
Alfonz.
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
- Bramdeman
- 480 Expert
- Posts: 656
- Joined: Fri Feb 20, 2004 8:52 pm
- Location: Pole position on the highway!
Its ok as long as it doesn't get worse and makes the clutch slip. But since you have the gearbox out it would be smart to fix it now. Take the clutch of the flywheel and then take the flywheel of the engine. Have a look at the crankshaft oilseal Thats problebly where your leak is.
'99 C70 2,3 T5 LPI Full option!
'98 V70 2.5Turbo LPI aircon ice etc etc <---Wrecked, she saved my life
'82 Porsche 928S 300HP 4,6V8 (scary)
'89 Red Turbo All Fixed up SOLD
'90 ES Lavender Metallic Automatic
'93 Two Tone Turbo!! Beauty! daily driver
'92 Red ES automatic
'88 340 1,7 Project car
'98 V70 2.5Turbo LPI aircon ice etc etc <---Wrecked, she saved my life
'82 Porsche 928S 300HP 4,6V8 (scary)
'89 Red Turbo All Fixed up SOLD
'90 ES Lavender Metallic Automatic
'93 Two Tone Turbo!! Beauty! daily driver
'92 Red ES automatic
'88 340 1,7 Project car
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
- Bramdeman
- 480 Expert
- Posts: 656
- Joined: Fri Feb 20, 2004 8:52 pm
- Location: Pole position on the highway!
Yeah should be, pull out the old one and carefully hammer in the new onee. Grease it up with motoroil first.
'99 C70 2,3 T5 LPI Full option!
'98 V70 2.5Turbo LPI aircon ice etc etc <---Wrecked, she saved my life
'82 Porsche 928S 300HP 4,6V8 (scary)
'89 Red Turbo All Fixed up SOLD
'90 ES Lavender Metallic Automatic
'93 Two Tone Turbo!! Beauty! daily driver
'92 Red ES automatic
'88 340 1,7 Project car
'98 V70 2.5Turbo LPI aircon ice etc etc <---Wrecked, she saved my life
'82 Porsche 928S 300HP 4,6V8 (scary)
'89 Red Turbo All Fixed up SOLD
'90 ES Lavender Metallic Automatic
'93 Two Tone Turbo!! Beauty! daily driver
'92 Red ES automatic
'88 340 1,7 Project car
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
- rpruen
- Friend of Club 480 Europe
- Posts: 2299
- Joined: Wed May 26, 2004 9:09 pm
- Location: Near Bristol (uk)
The seals are not that easy to remove.
Best thing is to screw a self tapping screw into the flat part of the seal, then use a claw bar, or claw hammer to gently pry the seal out. It may take a few goes, but it's less messy than trying to mangle the seal with a screwdriver. IT's also less likely to scratch the part of the crankshaft the seal runs on (that would not do the new seal any good).
Richard
Best thing is to screw a self tapping screw into the flat part of the seal, then use a claw bar, or claw hammer to gently pry the seal out. It may take a few goes, but it's less messy than trying to mangle the seal with a screwdriver. IT's also less likely to scratch the part of the crankshaft the seal runs on (that would not do the new seal any good).
Richard
Car Status: Squashed :(
Now have 765 GLE 2.8 V6
Now have 765 GLE 2.8 V6
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
hey, i got me box!!
45 notes + found a cheap courier see below, 8.75 + vat next day!!!!
http://www.interparcel.com/courier-quote1.php
hopefully have a go at fitting this weekend
45 notes + found a cheap courier see below, 8.75 + vat next day!!!!
http://www.interparcel.com/courier-quote1.php
hopefully have a go at fitting this weekend
Alfonz.
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
- Dan the 480 Man
- 480 Is my middle name
- Posts: 2269
- Joined: Thu Jan 08, 2004 7:42 pm
- Location: No longer in a Volvo...(But not forever!)
- Contact:
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
PLEASE tell me ther arent 2 sizes/pitches of splined drive shaft that fit into the gear box. (off side)
been wrestling with this gearbox all afternoon & have barely got any skin left on my arms, I just cant get the drive shaft to engage.
help
been wrestling with this gearbox all afternoon & have barely got any skin left on my arms, I just cant get the drive shaft to engage.
help
Alfonz.
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
- chris1roll
- Friend of Club 480 Europe
- Posts: 3927
- Joined: Wed Feb 12, 2003 6:50 pm
- Location: Using LOTS of petrol!
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
- alfonzobonzo
- 480 Rookie
- Posts: 454
- Joined: Mon Dec 13, 2004 1:05 pm
- Location: taste that Otter Ale
- Contact:
got the box in, in about 3 minutes on saturday, dunno what went wrong the other day, i must have just been being crap,
the shaft doesnt have to be orientated in any way whats so ever, exept obviously you want the holes to line up.
the shaft doesnt have to be orientated in any way whats so ever, exept obviously you want the holes to line up.
Alfonz.
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)
Toyota Celica G7 Tsport Storm Blue (LiftTastic)
480 L 1994 2.0 i Metalic Black K&N Panel SOLD (fond memories)
V40 W 2000 1.9 T4 SOLD (kind of miss it)